TOM KRISHER, AP Auto Writer
DETROIT (AP/WWJ) — General Motors’ efforts to root out lingering safety problems across its wide range of cars and trucks has produced another big recall — and highlights a sudden shift at GM and throughout the industry toward issuing recalls instead of avoiding them.READ MORE: 50 migrants found dead in back of tractor trailer in San Antonio
Meanwhile, the federal government says it will make a “major announcement” about its investigation into GM’s recalls.
U.S. Secretary of Transportation Anthony Foxx and the National Highway Traffic Safety Administration’s Acting Administrator David Friedman are holding a press conference at 11:15 a.m. in Washington D.C.
The nation’s largest automaker announced a total of five recalls covering 2.7 million vehicles Thursday. The biggest involves 2.4 million midsize cars from model years 2004 to 2012 with brake lights that can fail.
GM acknowledged it knew about the brake light problem as early as 2008. That year it issued what’s known as a technical service bulletin, but that only required dealers to offer to fix the problem if the owner became aware of it. Such bulletins typically cover problems an automaker considers minor, and avoid the larger cost of a recall. But a driver’s safety could be jeopardized by unknowingly operating a car with a defective part.
In announcing the recall, GM said the brake light problem has been tied to 13 accidents and 2 injuries.
GM launched a top-to-bottom safety review after recalling 2.6 million small cars earlier this year for faulty ignition switches. GM knew about that problem for at least a decade, issuing service bulletins years before it started to recall the cars. The switch problem, which can unexpectedly shut down a car’s engine, has been linked to at least 13 deaths and has prompted multiple investigations, including one by the Justice Department.
“These additional recalls underscore how important it is to keep the pressure on GM to make sure the company is being as transparent as possible,” said Sen. Clare McCaskill, D-Missouri, who heads a Senate subcommittee looking into GM’s handling of the ignition switch problem.
The recalls could also add to scrutiny of federal safety regulators, who were criticized for their handling of the ignition switch problem. Documents filed with the National Highway Traffic Safety Administration show that neither the company nor the government sought a recall to fix the brake light issue despite 1,300 consumer complaints and more than 14,000 warranty claims as of February of last year.
The agency said in a statement Thursday that an investigation it opened into the problem last year influenced GM’s decision to recall the cars.
Jeff Boyer, GM’s newly appointed safety chief, said GM now will recall cars as soon as it sees a safety problem. The company, he said, has added 35 safety investigators to its team as it sifts through records looking for cars that should have been recalled earlier.READ MORE: Tampa Bay LGBTQ+ Community Fears Future SCOTUS Decisions Following Roe v. Wade Reversal
“We’re not waiting for warranty trends to develop over time,” he said. “It’s not only about frequency, it has to be about seriousness of the potential defect as well.”
GM has now recalled more than 11 million cars and trucks in the U.S. so far this year, close to its annual recall record of 11.8 million set in 2004.
The auto industry also is on track to set a single-year record for U.S. recalls. Companies have recalled 15.4 million vehicles in a little more than four months, according to government records. The old single-year record for recalls is 30.8 million vehicles in 2004. Toyota, Ford, and Chrysler also have announced sizeable recalls this year.
Industrywide, automakers are moving faster to fix problems than they have in the past in a bid to avoid bad publicity and record fines from government agencies.
“All manufacturers are recalibrating their recall programs to go from ‘if in doubt, don’t recall’ to ‘if in doubt, recall,'” said Clarence Ditlow, executive director of the nonprofit Center for Auto Safety.
Earlier this year, the Justice Department made Toyota pay a $1.2 billion penalty and admit to concealing problems with unintended acceleration in its cars and trucks. That fine and the GM investigation — which could bring criminal charges against individuals — have changed the way automakers view recalls.
GM said the recalls announced Thursday also will fix problems with headlamps, power brakes and windshield wipers. The Detroit automaker will take a $200 million charge this quarter, on top of a $1.3 billion charge in the first quarter, mostly to cover the repairs. GM shares fell 1.7 percent to close at $34.36.
The auto industry set the standing recall record in 2004 after U.S. laws were changed requiring them to report more defects to the National Highway Traffic Safety Administration. Experts also blamed the high number on vehicles that rely more heavily on computers, more common parts across each company’s model lineup and more safeguards at litigation-sensitive automakers to catch flaws earlier.
AP Auto Writer Dee-Ann Durbin contributed to this report.MORE NEWS: Some US Companies Will Cover Travel Costs For Employees Who Need An Abortion
Copyright 2014 The Associated Press. All rights reserved. This material may not be published, broadcast, rewritten or redistributed.